SZL Series Double Drum Coal Fired Steam Boiler

Recently, the Ministry of Environmental Protection by the volatility of the newly revised "Boiler Air Pollutants Emission Standards" released in July this year, the implementation of this standard is known as by far the most stringent air pollution emission standards for boilers, boiler caused by the manufacturing sector.

Compared with the existing standards, new standards not only revised the traditional particulate matter and sulfur dioxide emission limits, for the first time proposed emission control standards for nitrogen oxides and mercury, Forced boiler manufacturers have to upgrade technology, from the source control boiler discharge atmospheric pollutants.

One side is desulphurization and denitrification entered the final stage, while the new emission standards of air pollutants are being introduced amendments to the boiler. Such as pollutant emissions from large wide range of small capacity monomer emission coal-fired boilers and other issues close to the ground long standing will once again be enlarged, comprehensive improvement of coal-fired boilers will undoubtedly become the next focus of urban air pollution control. Analysts believe that the implementation of the new standard direct-driven investment in environmental protection will reach 370 billion yuan to 4500 yuan, while the boiler manufacturing industry is facing exams has also led to the relevant environmental protection equipment market to break out again.

By the end of 2011, our country in the boiler 620,300 units, of which 09,700 units utility boilers, industrial boilers 610 600 units, with a total capacity of about 3,515,900 kilowatts. In 2012, industrial boilers reached 62.4 million units, about 98% of the total number of boilers.

In industrial boilers, coal-fired boiler is more than 80%, the annual consumption of 490 million tons of standard coal, the average efficiency of 65% to 70%, emissions remain high.

In 2012, coal-fired industrial boilers cumulative emissions of dust 4.1 million tons, 5.7 million tons of sulfur dioxide, nitrogen oxides 2.0 million tons respectively, accounting for 32% of total national emissions, 26% and 15%, a major cause of fog and haze one of the reasons.

For this reason, in the 2013 set off a nationwide clean energy alternative coal-fired boiler boiler, more than one place Shandong, Shanxi and other relevant measures have been introduced on clean energy alternative to coal-fired boiler work. "The introduction of the implementation of the most stringent standards, will set off a coal-fired boiler in the second round.

Four existing small and medium sized coal-fired boilers in China. One pollutant emissions from large, wide surface. Second, small-cell capacity, the average capacity of 8 tons / hour, the number of 10 tons / hour of small coal-fired boilers is 42 million units, accounting for two-thirds of the total. Third, emissions close to the ground, a great impact on quality. Fourth, boiler technology, main and auxiliary mismatch, poor health. In addition, most small boiler lack of dust removal, desulfurization and denitrification equipment, led to the current sulfur dioxide and dust emissions from boilers widespread non-compliance.

From the present point of view, domestic clean energy technology matures, the implementation of new emission standards for technology development has brought very good driving force for the future, who can stable up to standard technical requirements of the country, will have a presence in the market value Otherwise it can be eliminated.

IBR CFB Steam Boiler

ZG manufactured IBR CFB steam boiler can be distinguished into new type water cooling whirlpool inner separation low speed circulating fluidized bed boiler and energy saving circulating fluidized bed boiler. IBR CFB steam boilers’ capacity is among 15 to 280 ton/h. IBR CFB steam boiler can also be divided into coal fired CFB steam boiler and biomass fired CFB steam boiler. CFB steam boiler can be widely used into paper industry, textile industry, oil refineries, power plants, chemical industry, glass plants, and so on. Besides, 75 ton coal fired CFB steam boiler is the hot sales product in our ZG Boiler.

Well designed and optimized the small series main parameters of szl series double drum coal fired steam boiler maintenance check before delivery of submersible pumps confirm Henan fast boiler us with all the main parameters of the steam boiler optimization design and delivery of well maintenance check before confirming with submersible pumps steam boiler with other boiler Like products, in order to improve the combustion efficiency of the boiler must optimize the product, this article lists the following items index to optimize the design parameters and performance indicators as steam hot water boiler for reference purposes only. (1) to ensure safe operation of the hot water boiler steam: hot water boiler steam integral part life more than 30 years, the life by wear of the heating surface reaches more than 15 years. (2) Operation Economy excellent hot water boiler steam: Steam hot water boiler efficiency of 91% -93%, 99% combustion efficiency; small soda system flow resistance, reducing the power consumption of the feed pump; reduced gas side resistance losses, reducing blower, fan, and other auxiliary equipment mill power consumption. (3) has a good regulation performance: adjusting the combustion, steam temperature adjustment, like the boiler drum water level regulator flexible and effective. (4) investment cost savings: Enhanced heat transfer, reduce the consumption of metal, especially a reduction in the consumption of advanced metallic materials; under the premise of ensuring product quality, reduce manufacturing, transportation, construction and maintenance, operating costs. (5) High Reliability Run: available more than 90%, fewer unplanned downtime; fire, deflagration, and no accident slagging operation of the steam boiler hot water; heating surface leakage and over-temperature occurs, tube rupture. (6) has a good load following properties: rapid start and stop, load change quickly. (7) running stability: stable operation of the steam boiler parameters, thermal stress is small and easy to adjust automatically with coal and load changes. (8) slight heating surface wear, less fouling, corrosion, emissions meet environmental requirements. Check well before delivery inspection confirmed ① out with submersible well pumps, valves, and pre-population with submersible pumps line valve closed; ② confirmed wells with submersible pump inlet line valve closed temporary purged with nitrogen, removal of temporary hose, cap installed; ③ confirmation discharge line valve closed torch; ④ confirm the submersible well pump has been fully emptied medium (neat) with; ⑤ discharge line to confirm a closed valve closed; ⑥ confirmed vent valve opening (Ming row); ⑦ confirm submersible well pump body temperature was lowered to room temperature; ⑧ contact operating position within the pump power corresponding to the apparatus; ⑨ card to send electrical power plant, the pump power; ⑩ confirm that the pump motor off.

You must know the problems of energy consumption boiler (boiler thermal efficiency) 1, because the thermal efficiency of boiler problems of a high exhaust gas temperature. b sootblowers into low. c ash combustible large. d is too large or too small boiler oxygen. e heat loss is large. f large air preheater air leakage rate. g coarse pulverized coal. h steam - water quality is poor. I defective equipment, operating parameters are forced down. 2, measures to solve the problem of a lower exhaust gas temperature. b timely elimination of soot blowers defects and improve the investment rate of soot blowers. c reduce fuel ash, slag combustibles. d control the amount of oxygen in the boiler. e reduce heat loss. f air preheater to reduce air leakage rate. g qualified coal fineness control. h to improve the quality of soft drinks. i According to circumstances, the boiler heating surface adjustment arrangement. J burner when necessary transformation to fit the gaseous fuel.

SZL Series Double Drum Coal Fired Steam Boiler Related Information

SZL Coal Fired Double Drum Steam Boiler_TAIGUO

Introduction of SZL Coal Fired Double Drum Steam Boiler: SZL Coal Fired Double Drum Steam Boiler is D-type layout, horizontal style, low pressure and double-drum offset hearth. Suitable for large capacity over 5tons/h. Fuel feeding method is automatic which saves a lot of labor.

Get a Quote

Automatic Type SZL Series Coal & Biomass Boiler

2020-2-5 · TAIGUO SZL coal/ biomass fired traveling chain grate boiler adopting double drum (upper drum, lower drum), membrane water cooling wall. Usually this structure is common to see in power plant boiler, because big heat transfer surface and double drum can ensure strong and steady steam

Get a Quote

SZL Series Steam Boiler

2018-10-19 · SZL Series Boiler is horizontal type double drum longitudinal type chain grate water tube steam boiler and hot water boiler .This series boiler has reached the international, advanced level at technology,performance, environment protection.

Get a Quote

China Szl Series Industrial Coal Fired Steam Boiler

Product Description. Industrial chain grate coal fired steam boiler. 1.The boiler shall adopt double drum,monolayer arrangement,compact structure,as well as large heating surfaces which are more 10% than those of same kinds of products,featuring the following advantages such as sufficient output,safe and reliable operation,short construction period,low installation cost ect.

Get a Quote

China Szl Boiler, Szl Boiler Manufacturers, Suppliers

China Szl Boiler manufacturers - Select 2020 high quality Szl Boiler products in best price from certified Chinese Boiler manufacturers, Oil Boiler suppliers, wholesalers and factory on Made-in-China.com

Get a Quote

Automatic Type SZL Series Coal & Biomass Boiler

2020-2-5 · TAIGUO SZL coal/ biomass fired traveling chain grate boiler adopting double drum (upper drum, lower drum), membrane water cooling wall. Usually this structure is common to see in power plant boiler, because big heat transfer surface and double drum can ensure strong and steady steam

Get a Quote

Szl Double Drums Steam Boiler - Het Koerhuis in Epen

low price szl series coal fired hot water boiler Gas . 2017-12-8 · coal fired steam boiler,coal fired hot water boiler-ZG Boiler The SZL assembly coal fired boiler,was developed in the 80s as a new type of water SHL series coal fired boiler is the fourth-generation chain grate boiler high thermal efficiency,low operation cost,long-term trouble-free operation,lightw .

Get a Quote

Szl Series Double Drum 6t/h Coal Fired Steam Boiler -

Szl Series Double Drum 6t/h Coal Fired Steam Boiler, Find Complete Details about Szl Series Double Drum 6t/h Coal Fired Steam Boiler,6t/h Coal Fired Steam Boiler,6t/h Steam Boiler,Double Drum Steam Boiler from Boilers Supplier or Manufacturer-Henan Province Sitong Boiler Co., Ltd.

Get a Quote

double-drum coal fired steam boiler Industrial boiler

2017-7-22 · SZL Series 25 ton Double Drum Coal Fired Steam Boiler for Textile Sep 2, 2016 Product Description: SZL series steam generator is the double drum longitudinal type chain grate steam generator. It is designed by our Double drum chain grate coal fired steam boiler 10ton boiler John

Get a Quote

double drum szl boiler ZOZEN Boiler

Double Drum Steam Boiler, Double Drum Steam Boiler Supplie. SZL(D)Type double drum steam boiler for laundry machine SZL series double drum steam boiler was manufactured by Henan Yuanda Boiler Co.,ltd,this boiler is main used in industrial,this boiler fuel is most suitable for biomass,connut shell,rice husk,ri. [email protected] > Get A Quote >

Get a Quote

SZL water tube coal biomass steam boiler_TAIGUO

Introduction of SZL series automatic chain grate steam boiler: SZL series water tube steam boiler is also named automatic chain grate boiler, with D-type layout, horizontal style, low pressure and double-drum offset hearth.Suitable for coal/biomass fuel, environmental friendly and energy saving. Fuel feeding method is automatic which saves a lot of labor.

Get a Quote

Double-drum Chain Grate Steam Boiler India,Water

2019-11-28 · SZL series assemble chain grate steam boiler, double-drum, water tube boiler, with strong overload capacity and a wide range of coal adaptability is a best choice for supplying steam in textile, printing and dyeing, paper making, chemical industry, and food industry.

Get a Quote

SZL series biomass-fired steam boiler - Biomass-fired

SZL series biomass-fired steam boiler is package or shop-assembled water tube boiler with double steam drum and chain grate stoker structure. 4-6 tph boiler is package boiler and 6-35 tph is shop-assembled structure, which is composed of 2 parts, upper part is heat absorbing surface and lower part is combustion equipment.

Get a Quote

China Best Double Drum Coal Fired Boiler - WHGLA

industrial szl double drum steam boiler - hieroglyphs.in. best selling chinese industrial solid fuel boiler - SZL . 2013-7-22 · II. SZL series double drum coal fired boiler description: This series boiler belong to double drums water tube boilers,designed for bloedown on surface,and the quality of steam is

Get a Quote

SZL Series Coal Fired Steam Boiler,Coal Burning Boiler

2020-1-18 · SZL series water tube steam boiler is designed by our engineer based on the advanced technology in domestic and international, which is the horizontal type double drum longitudinal type chain grate water tube boiler, it contains both steam generator and hot water boiler. This series boiler has reached the international advanced level on

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top