2 tons integrated natural gas hot water boiler

Fangkuai Boiler is a clean-up boiler equipment based on various excellent scientific and technological advancements, focusing on product development, manufacturing, and manufacturing that are more efficient, environmentally friendly, and energy saving, and meet the basic national conditions of environmental protection in China. In order to promote the rapid development of the heating furnace manufacturing industry, people-oriented, consider the specific requirements of customers in the manufacturing industry for heating furnaces in various industries.

Tail secondary combustion flue how to deal with the phenomenon of a sharp increase in rear of the boiler flue secondary combustion flue temperature location and later. 2, the furnace, the flue abrupt change in negative pressure, flue gas is not tight at the smoke, the Mars. 3, air preheater large current swing bearing housing temperature, severe Jam occurs. 4, air preheater fire alarm issue. 5, steam temperature, economizer outlet water temperature, the air temperature rises abnormally. 6, induced draft fan vanes automatically open a large, Fan current rise. 7, as the combustion side, both sides of the smoke temperature difference increases. Reason 1, through the coarse fine grinding coal, coal poor uniformity, improper adjustment of combustion, combustion of fuel is insufficient, serious mechanical incomplete combustion, and high levels of combustible ash accumulated in the back pass. 2, an oil burner or an oil poor atomization, so that unburned droplets deposited in the flue. 3, prolonged low load operation of boiler, the furnace temperature is too low or too small amount of excess air resulting in incomplete combustion of coal or oil accumulated in the tail. 4, after the shutdown of the fuel leakage into the furnace and accumulates or after shutdown and to insufficient MFT furnace purge unburnt coal or oil accumulation at the end of the tail. 5, soot blower failure, long-term put into operation is not normal. 1 process, when a slight secondary combustion, exhaust gas temperature does not rise within 20 ℃ normal smoking temperature should be checked immediately paragraphs, the combustion site and judge whether the secondary steam soot blowing. (When the exhaust gas temperature rises to 250 ℃) 2, the operation of the back pass and then generating boiler combustion boiler operation should be stopped immediately, immediately stop sending, ID fan and turn off all the smoke and steam soot blowing air damper fire. 3, if the economizer afterburning, until the storage tank level control valve blocking off without pressure, flow rate of feed pump motor start 150t / h Sheung be cooled. 4, air preheater heating surface of the secondary combustion air preheater normal operation, normal operation of the air pre-heater holder; air preheater Jam occurs, the main drive motor and the auxiliary drive motor trip, contact maintenance manual plate moving continuous air preheater rotor. Soot blowing steam into air preheater for extinguishing, into the air preheater for fire extinguishing can not be extinguished. 5, the economizer outlet water temperature close to the inlet temperature (at the economizer secondary combustion), the air preheater inlet gas temperature, exhaust gas temperature, the hot air temperature is lowered to less 80 ℃, each one hole, and the hole is no longer Mars smoke and soot blowing steam stops coming out after water or fire. Open hole inspection manhole and inspection to confirm the secondary combustion goes out, after the flue vent door open to drain water inside the smoke flue opening for ventilation air damper. 6, to be re-combustion is resolved, the flue temperature does not rise and fall when stabilized, before slow regulation of the air, smoke baffle, the necessary air cooling and purging.

First, the design principle WNS type boiler and a gas main features. 1, WNS type boiler design principle and structure: WNS is a wet back boiler shell three-pass horizontal fire tube boiler, this structure uses three return, the oil mixed with air or gas well through the atomizing burner, in the complete combustion furnace in a corrugated, folded from the rear chamber into the first tobacco smoke return tube, to a second smoke box to the front return pipe tobacco, tobacco after entering the last tank, is discharged from the chimney. It has strong adaptability to different fuels, combustion of heavy oil, light oil, natural gas, city gas. Low power consumption, load regulation ratio. Boiler automatic control, adaptability of the burner. Using imported burner, reliable performance, high degree of automation. 2, the main features of the WNS type boiler: High (1) combustion efficiency, safe and stable, space-saving, fuel-saving, low investment costs to buy fuel; (2) full-pull edge butt welds, boiler safety, long life, maintenance costs low. (3) there is arranged a tail flue gas condensation recovery, can effectively control the exhaust gas temperature, high thermal efficiency of the boiler; (4) with automatic burner, water continuous electric adjustment, high combustion efficiency. (5) The quick configuration, the entire boiler design on the steel strong base, easy installation and transportation, saving the boiler room floor space area. Two, SZS type gas boiler structure and characteristics: SZS longitudinal type double drum "D" type arrangement quick water boiler. It consists of upper and lower drum, membrane wall, the convection tubes, condensers, and economizer, disposed in the front wall of the burner, the combustion of the fuel in the furnace, flue gas convection bank, an economizer and a condenser into the chimney. The main features are: (1) The double boiler drum "D" type arrangement, compact, small footprint, good flame fullness. (2) the boiler supporting mode can be free to expand upwards. (3) furnace wall and membrane in all convection pass wall structure, good sealing and maintenance work and reduce the use of refractory bricks. (4) The quick boiler structure can effectively shorten the installation cycle. (5) arranged economizer tail, can effectively reduce the exhaust gas temperature, high thermal efficiency of the boiler. (6) The whole boiler steel seat strong base, easy transportation and installation. (7) having a heating surface surplus, soda and a sufficiently large space to ensure stable boiler parameters. (8) with automatic burner, combustion efficiency and an ignition control program and overpressure, flame protection. Third, the application type WNS and SZS boiler used in Example 15 t: In addition to evaporation, working pressure, as the fuel is used, the two contrast, WNS size slightly smaller type gas boiler, small footprint, from a cost perspective, slightly lower than SZS type gas boiler, the thermal efficiency of the boiler is almost the same, but their difference only lies between 1 t -20 t tonnage, the conventional WNS type gas boiler, and SZS-type gas-fired boiler more than 4 tons -60 tons, even to 90 tons.

SZS series gas-fired superheated steam boiler project for heating industryXinzheng Heli Thermal Co., Ltd. is a company specializing in heat energy production and central heating supplying, providing heat source for winter heating for people in Xinzheng . Facing the increasingly serious environmental problems, Xinzheng Heli decided to respond positively to the "coal to gas" policy, using clean energy natural gas as boiler fuel and introducing high efficient gas-fired boilers to replace the original coal-fired boilers. For this, Xinzheng Heli Thermal carried out an open bidding. After competitive bidding and strict selection,ZOZEN defeated other competitors and won the bid with its comprehensive corporate strength. The winning bid was ZOZEN energy saving and environmental protection product - SZS series condensing gas-fired superheated steam boiler (3 sets of SZS75-1.6-Q). The furnace and the front and rear walls of this series of boilers adopt membrane water wall structure, and the airtightness is good. The large furnace design is combined with an advanced ultra-low NOx burner to ensure sufficient fuel combustion, controlling the NOx emissions below 30mg/m³ and the thermal efficiency up to 98%. At the same time, the boilers adopted the flue gas recirculation technology and were equipped with economizers and condensers at the tail of the boiler flue, which not only followed the concept of energy conservation and environmental protection, but also met the thermal energy requirements required by the project.

2 tons integrated natural gas hot water boiler Related Information

2 tons hot water boiler for heating - ferienhaus

2 tons of gas water boiler - andrehupet-artiste.be. boiler 2 tons Hot Water Boiler For School. boiler (2) tons YouTube. 4/29/2011 · it shows you that an old boiler we have here will be exactly as a new boiler.2 Ton Gas Boiler, 2 Ton Gas Boiler Suppliers and Alibaba.com offers 4,595 2 ton gas boiler products.

Get a Quote

10 tons natural gas steam boiler -

Free Online Consultation; 10 Tons Gas Steam Boilers Prices - 10 Tons Natural Gas Fired Boiler to Peru Model SZS series water tube boiler Capacity 10 ton Application food industry As a ASME certificated factory, we have sold many steam boilers and hot water boilers under its standard.

Get a Quote

2 tons hot water boiler for heating - ferienhaus

2 tons of gas water boiler - andrehupet-artiste.be. boiler 2 tons Hot Water Boiler For School. boiler (2) tons YouTube. 4/29/2011 · it shows you that an old boiler we have here will be exactly as a new boiler.2 Ton Gas Boiler, 2 Ton Gas Boiler Suppliers and Alibaba.com offers 4,595 2 ton gas boiler products.

Get a Quote

Cleaver-Brooks Boilers Firetube CBLE

2020-2-7 · Steam and hot water; 125 to 800 HP; Natural gas, #2 and #6 oil, combination ; 15 to 250+ psi on steam, 30 to125 psi on hot water; Available to ; 9 ppm NOx; The Cleaver-Brooks Model CBLE is a dryback firetube boiler designed with a completely integrated integral burner offering the highest efficiencies and emissions levels down to 9 ppm NOx.

Get a Quote

10 Tons Boiler For Industry - dorfwirt-hagendorf.de

10 tons steam boiler gas for extractive distillation. 10 tons steam boiler gas for extractive distillation Technoeconomic analysis and lifecycle assessment The excess steam produced in the boiler is converted to electricity for use in the plant and for sale to the grid as a coproduct. the butanol and water azeotrope can be broken by extractive distillation using a solvent, similar to extractive

Get a Quote

Integrated condensing natural water tube hot water

1 Mw Natural Gas Fired Hot Water Boiler Stainless Tub. WNS 2.8mw industrial fire tube natural gas fired hot water . WNS 2.8mw industrial fire tube natural gas fired hot water boiler price Introduction Introduction 1.Exceptional steam quality, outstanding energy efficiency, and flexible output for fluctuating steam demand makes the biomass 3-pass

Get a Quote

4 Tons Natural Gas Boiler - lazarusfoundation -

natural gas power plant boiler price gas oil powerFue. 2019-4-26 · As a leader in industrial boiler manufacturers, offers 0.5-130 ton with pressure up to 9.81MPa / 98.1bar industrial gas and oil steam boilers, hot water boilers and power plant boilers.

Get a Quote

Integrated condensing natural water tube hot water

1 Mw Natural Gas Fired Hot Water Boiler Stainless Tub. WNS 2.8mw industrial fire tube natural gas fired hot water . WNS 2.8mw industrial fire tube natural gas fired hot water boiler price Introduction Introduction 1.Exceptional steam quality, outstanding energy efficiency, and flexible output for fluctuating steam demand makes the biomass 3-pass

Get a Quote

11 tons natural gas steam boiler - twist-communicatie.nl

10 tons Integrated natural gas hot water boiler - Gas Consumption of 10 Ton Gas Boiler Per Day--Gas Consumption of 10 Ton Gas Boiler Per Day 2018-01-26 11:00:03 The output steam of 10 tons natural gas boiler per hour is 10 tons, which is the capacity of the boiler. If we want to calculate the amount of fuel gas consumed in a .

Get a Quote

2 Ton Natural Gas Fired Hot Water Boiler

2019-12-4 · China Hot Water Boiler Manufacturer. As the outstanding industrial hot water boiler supplier in China, the high efficiency natural gas fired hot water boiler is very popular on the globe, and ZG's industrial steam boilers and hot water boilers have been exported into many countries, for example Pakistan, India, Russia, South America, etc.

Get a Quote

Four Tons Of Gas Boiler - Dorfwirt Hagendorf

four tons of steam boiler - claremontdelhi.co.in. 4 tons of gas steam boiler Chain Grate Steam Boiler 4 tons of gas steam boiler Posted on April 9, 2019 by steamboilerinpakistan Quick inquiry: I need the quotation of Pls Select Product Thermal oil Boiler Electric Boiler Steam Boiler Hot Water Boiler Hot Air Boiler, the fuel is, the pressure

Get a Quote

Integrated water tube hot water boiler for sale

0.7MW water tube steam boiler Industrial steam boiler The 0.7MW(700KW) hot water boiler for sale is used particularly readily in hospitals, homes, office buildings, residential complexes as well as throughout all 0.7MW(700KW) hot water boiler zgsteamboiler.com0.7MW(700KW) hot water boilers are a unique three pass, dual fuel (natural gas & #2

Get a Quote

Integrated condensing natural water tube hot water

1 Mw Natural Gas Fired Hot Water Boiler Stainless Tub. WNS 2.8mw industrial fire tube natural gas fired hot water . WNS 2.8mw industrial fire tube natural gas fired hot water boiler price Introduction Introduction 1.Exceptional steam quality, outstanding energy efficiency, and flexible output for fluctuating steam demand makes the biomass 3-pass

Get a Quote

20 tons boiler gas water boiler - niedenfuehr.de

20 ton szs gas fired boiler in pharmaceutical factory. 20 tons h oil fired boiler - philip-morris . 20 tons natural gas steam boiler Product - happypvtiti.in. 5 Tons Biogas Steam Boiler Price - kantidarshan.in. 6 ton gas boiler supply hot water boiler,industrial steam What is the gas consumption of the 2 t/h natural gas fired steam boiler Mar 14, 2017 Product: 2 ton/hour 2000kg/hr gas fired steam

Get a Quote

30 tons hot water boiler - SRM University

industrial 2 ton gas boiler -2 tons pressure hot water Gas hot water boiler 20 tons sigmaster.pl. Compared to 10 ton gas boiler and 20 ton gas boiler, the application of 30 tons gas steam boiler and 30 ton gas hot water boiler is relatively small, but the application of customers in industrial production or heating is larger.

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top